Telephone System Install

 

Telephone System Install

by rdpecken on Jul.07, 2010, under Communications

We finally got the phone system installed at the Ranch. It ends up looking like this:

 
Phone Booth

It has a 20 watt solar panel charging a Marine battery to run the whole thing.

So, from our last trip up, we concluded that we needed a bigger box or two (or three).  I ended up finding all I needed at Bass Pro Shop in Mesa.  They had a large Ammo Box that was big enough for the 75 Amp Hour battery…

 
Ammo Box 

 
Battery Box
 
 

They also had some smaller ammo boxes with lock rings that were just the right size for the electronics.

 
Small Ammo Box

All of the electronics was fitted into the three boxes, and mounted on a pole.  When I went to plant the pole in the spot chosen on our last trip, I found that there was a ledge of limestone just 6 inches down.  I could not dig through it, so I needed to find a new spot.  I ended up hiking around the property until I found another spot that had 2 bars on the cellphone.  The good news was that it was even closer to the house.  The bad news was that it was on the side of the mountain!

 
View to the LittleHouse from the Phone Booth

 

So I dug a hole to plant the pole up there.  Again, I could not go as deep as I wanted, but managed to get down 14 inches.  After carrying up the pole and all of the electronics, I set the pole in the hole and started mixing cement.  Once the hole was filled, I stacked rocks around the pole above ground and used the remaining cement to mortar them together to form a sort of pyramid to help support the post.

 
Phone Booth with Rock Base

So it works like this… When we arrive at the Ranch, I hike up the hill (2 minutes) and turn on the power supply from the battery that has been charging since the last time we were up.

Power Supply

Next, I put the cellphone in the top box and lock it. The USB cable from the inverter provides charging current to the cellphone, so it won’t run out of battery.

 
Cellphone Box

Next, I put the cordless phone handset into the base unit for a few seconds to sync them up.  I wish I didn’t have to do that, but with the old tech cordless phone, it is necessary.  The Bluetooth gateway has already sync’d to the cellphone, as indicated by the solid blue light on the bottom.

 
Gateway and Cordless Base

That box is then closed up and locked. From that point on, we have reliable phone service at the LittleHouse and surrounding area.  When we leave, we just reverse the procedure.

I may replace the 20 watt panel with a 30 watt in the future.  As it is now, the 20-watt doesn’t quite keep up on a day to day basis while the system is in use.  This generally isn’t a problem, because we are seldom there for more than 5 days in a row, and the battery easily carries us through that long, with the solar cells charging.  When we leave, there is less current drawn, so the charger has a chance to catch up.

But when we start staying here longer, I think we will need a bigger solar cell.

Comments

Post a Comment

Popular posts from this blog

Battery Upgrade for the LittleHouse

Image
 Over the past year or so, our batteries for the solar power system have been deteriorating.  This winter, I replaced just one of the eight 6 volt lead-acid batteries, in the hopes that it would improve operation until I could apply a fix in the spring. It worked for a while, but then other batteries in the string began losing their capacity to the point of the system going down nearly every day for a few hours before the sun rises each morning. I decided to bite the bullet and install a whole new string of batteries. On researching, it appeared that it would make sense to replace the old lead-acid battery technology with newer Lithium Iron Phosphate technology.  Not only are the new batteries considerably more compact and lightweight for a given capacity, they should also last much longer and require little maintenance. I decided the replace the eight batteries comprising the 48 volt, 200 amp hour lead acid string with two Lithium Iron battery packs of 100 amp hours each.  This matche
Read more

November 2022 Visit

Image
    With a cold front approaching, I decided to run up to the Ranch to winterize the water pipes before the sustained 20-degree days hit us later in the week. I rinsed out our 200 gallon water tank that we use to haul water from the standpipe in Seligman to our Ranch.  After loading up the tank in the truck, I headed for Seligman. There had been reports that the standpipe in town had been modernized to accept debit cards for thew water that is drawn.  But upon arrival to the standpipe, I found that people were inserting quarters, and found a note on the control that said the new system was "still not working". Luckily, I had a fist full of quarters in the truck that I save for carwashes, and things of that nature. When it was my turn, I used the quarters, and filled up the 200 gallon tank.  It cost about 20 cents per gallon, so $2.50 to fill the tank. I hauled the water up the hill and parked on a small slope near the LittleHouse to help get all of the water out of the tank. 
Read more

Installing the Ceiling in the Little House

Image
After a very long wait (with disease, inflation, and supply problems affecting the nation), we finally were able to put together a trip to install the tongue and groove ceiling at the Little House.   We had put this off during the pandemic, because supplies were very hard to get.  Then when lumber was available, the cost had more than doubled from pre-pandemic times.  Finally, after waiting it out, the prices of the 8-foot tongue and groove pine boards at the home center had dropped from nearly $15 per board to a little over $8 per board. I searched the store's online site for a location that had a large enough supply.  After seemingly found a store nearby, I put in an online order for them to pick a little over 100 boards from the 150 they said were in stock. Shortly later, we received an email telling us that the order had been cancelled, because they actually anly had 30-something in stock, and most of them were damaged in some way. So we went to another nearby store to look for
Read more